Synthetic fluids last longer and work better. This is different from the other Grand Cherokee applications. Mopar warranties do not cover the costs of repairing or replacing any part due to damage caused by poor or improper maintenance, contaminated fuels, or the use of fuels, oils, lubricants or fluids of a type other than those recommended in your Owner's Manual. Mopar Collision Replacement Parts Lifetime Limited Warranty This warranty is not transferable to a subsequent owner of the vehicle. There are two plugs on a transfer case one on the bottom to empty it and there is 1 on the top side for filling it , you will need a manual pump and the proper fluid ,pump in fluid slowly as to not over fill and watch for the fluid to start coming from the fill hole. Posted on Jan 04, 2010 forum. I have never looked into this type of thing before, always had the dealer do it.
To my knowledge this particular fluid is still a dealer only item. Axle cover bolt torque: Front and rear axle drain plug torque: 44 ft. If the truck is exposed to extremely dusty or muddy conditions, the oil should be changed at 1,000 mile intervals. Other designs may result in unsatisfactory cooling performance, poor gas mileage, and increased emissions. Trucks used for normal on-off road work should have the transfer case oil changed at 24,000 mile intervals. By continuing to browse our site you agree to our use of data and cookies. About three gallons should do it with some leftover.
For additional information, see the Global Shipping Programme This amount includes applicable customs duties, taxes, brokerage and other fees. Remove bottom then top to drain. Check with your parts house or dealer to make sure of what goes into the transfer case. There may be a drain plug. Allow to drain completely and clean gasket surface on cover and axle properly. Note: Antifreeze mixture must always be at least 44%, all climates year round.
Drive the truck until the engine has reached normal operating temperature, and park on a level surface. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitations or exclusions may not apply to you. Examples include: Garmin navigation, TomTom navigation, Katzkin leather, Koss headphones, truck bedliners, paint sealant and fabric protection. X X Inspect engine air cleaner filter, replace if necessary. The nv245 uses nv247 fluid. X Drain and refill transfer case 4X4. Warranty information on these parts is provided with the part or in its packaging.
Beyond the 24-month period, the Lifetime Limited Warranty covers replacement of the defective part only and does not include labor. It is important that the transfer case not be overfilled and that the correct fluid is used. X Drain and refill automatic tranmission fluid and change main sump filter 4. A variation may be observed from vehicle to vehicle due to manufacturing tolerance and refill procedure. We may receive commission if your application for credit is successful.
The nv245 uses nv247 fluid. Use the handy Links below to access over 40 years of Dan's product and vehicle specific Tech Notes to easily get the information you need for your vehicle's repair, maintenance, or upgrade project! Be careful not to take out the drain plug at the bottom. Beyond the 24-month period, the Lifetime Limited Warranty covers replacement of the defective part only and does not include labor. When vehicle and sales receipt for the original part are brought to the Authorized Dealer that sold the original part, consumer will receive a replacement part and any warranty service covered as shown above. When the vehicle is sold or otherwise disposed of i.
We use data about you for a number of purposes explained in the links below. Parts are covered on a replacement basis only, if the original part was sold over-the-counter. Mopar Limited Warranties do not cover any incidental or consequential damages connected with the failure of the part under warranty. X X Inspect brake linings. Mopar warranties do not cover the costs of damage caused by environmental factors or Acts of God. At the time of sale, a copy of the Limited Warranty and registration card found in the component packaging must be provided to the customer.
There is a small skid plate under it, and a large driveshaft leaves the rear end of the case heading to the rear differential axle. See the seller's listing for full details. Maximum protection -90d is provided with a 68% mixture protection. I'll see if he says anything. Fill with 75w140 fluid until at bottom of fill hole. However, the consumer may obtain replacement parts under warranty from any Authorized Dealer.
When the vehicle is sold or otherwise disposed of i. Oct 13, 2010 This is pretty straight forward once you have a few basic tools. It is recommended that the consumer takes the vehicle to the authorized seller who sold the part. When used for heavy duty work, trailer towing, snowplowing, and the like, the interval should be halved to 12,000 miles. The proper oil to use is 10W-30 or 10W-40 engine oil. This coolant offers the best engine cooling without corrosion when mixed with 50% distilled water.
Remove the drain plug from the bottom. Any excessive metal flakes in old lube indicates a problem with internal parts wear for either diffs or case. Consumer must pay the labor costs for installation of the replacement parts. If any such parts are defective during the warranty period, an Authorized Dealer will provide a replacement part. What Is Not Covered: Batteries that are discharged are not considered defective. The transfer case should have two threaded allen plugs or similar that are removed to drain and then refill the T case. ToDo list: programmer, exhaust, and a bunch of other stuff.